Audi TT MK2 8J Fuel Tank 8J0201021CH - Used Original Parts
RM 1,000
Condition: Used (Original)At a Glance
- Audi TT MK2 8J Fuel Tank 8J0201021CH - Used Original Parts
- Part number: 8J0201021CH / 065 / KBK0188704K
- Fits: Audi TT MK2 · confirm by chassis number before ordering
- Used Original · tested working
- RM 1,000 · final quote via WhatsApp
- M.S. Motor · Kuala Lumpur, Malaysia · ready stock
Diagnosis and Common Symptoms
A failing or corroded fuel tank on the Audi TT MK2 8J typically presents with fuel smell inside the cabin or boot area, visible fuel staining or wet patches under the rear section of the car, and inconsistent fuel gauge readings caused by a damaged sender unit flange or saddle deformation. Common fault codes logged include P0463 (Fuel Level Sensor Circuit High), P0462 (Fuel Level Sensor Circuit Low), and P0452/P0453 (Fuel Tank Pressure Sensor faults) when the EVAP system is compromised by a cracked tank body or failed vent valve seating. Drivers may also notice hesitation or fuel starvation under cornering if internal baffling or the fuel pump swirl pot has deteriorated. Physical impact damage from underbody strikes, rust-through on the tank straps or mounting points, and swollen or split plastic tank walls are the most frequent reasons for replacement on this chassis.
Introduction
This is a Genuine Used Audi TT MK2 8J fuel tank, removed from a donor vehicle and fully Tested for structural integrity, sender unit function, and seal condition before listing. Every unit goes through a visual and pressure check to rule out cracks, corrosion, or deformation that would compromise fuel delivery. Sourcing a Genuine used tank avoids the fitment guesswork and material inconsistency often found with aftermarket reproductions. Buyers get a factory-correct component with confirmed part number match, ready for direct installation.
Product Details
- Brand: Audi
- Model Compatibility: Audi TT MK2 8J (2006-2014)
- Part Name: Fuel Tank
- Part Number: 8J0201021CH
- Condition: Genuine Used (Tested Working)
- Notes: Inspected for cracks, corrosion, and internal contamination. Fuel level sender flange and mounting saddle checked for correct seating. Recommend replacing tank straps, seals, and clamps during installation for a fully sealed fit.
Frequently Asked Questions
How do I confirm this fuel tank fits my Audi TT MK2 8J?
Match the part number 8J0201021CH against the sticker or stamped code on your current tank, or check it against your vehicle's parts catalog entry, since Audi TT MK2 8J tanks vary by engine variant and market.
What symptoms indicate the fuel tank on an 8J TT needs replacing rather than just the sender unit?
If you see fuel odor in the cabin, visible fuel weeping from the tank body itself, or persistent P0452/P0453 EVAP codes even after replacing the pressure sensor, the tank shell itself is likely compromised and needs full replacement.
Does installing part 8J0201021CH require any coding or reset procedure?
No coding is required for the fuel tank itself, but if the fuel level sender is integrated and replaced along with the tank, the fuel gauge may need a brief relearn cycle through several ignition on/off cycles to recalibrate accurately.
Why choose a used Genuine tank over a new aftermarket one for the TT MK2 8J?
Genuine used tanks retain factory-correct baffling, saddle shape, and mounting geometry that aftermarket units frequently get wrong, and since this component rarely wears out under normal use, a tested used unit offers full reliability at a fraction of new dealer pricing.
What should be replaced alongside the fuel tank during installation?
Always fit new tank strap bolts, rubber isolation pads, and the main seal gasket, since reusing old hardware on a corroded 8J TT undercarriage is a common cause of post-installation leaks.
Part price does not include installation. Our workshop can install for you, labour is charged separately and confirmed with you before any work starts.
We cannot diagnose your car over WhatsApp or photos. Not sure this part will solve your problem? Come for a workshop check, diagnosis fee RM180. If you proceed with the repair using our parts, the RM180 is offset into the labour charge. If you decide not to repair, only the RM180 applies.
All parts are tested and guaranteed to work. Whether a part solves your car's problem can only be confirmed by diagnosis.
Shipping: from Kuala Lumpur, West Malaysia ~RM50, East Malaysia ~RM80 (estimate, confirm via WhatsApp). Delivery 1-2 working days in secure anti-static packaging.
Warranty: 30-day exchange for control units, engines, gearboxes and other major parts; 14 days for small parts. Claims require proof of installation by a qualified workshop. No warranty for items opened, modified, or damaged by wrong installation.
Prices vary with stock and part condition. Final price via WhatsApp.
Original Parts
Quality European Originals
Fast Delivery
Nationwide Shipping